900RR 95 KNOCKING IN THE CLUTCH

13809 Views 41 Replies 7 Participants Last post by bladeracer, Jul 1, 2013

Busted9R

Discussion Starter · Dec 30, 2009 (Edited)

ok so i cleaned my carbs and got the bike started after sitting for 8 months its got like a knocking on clutch side

rough at idle but smooths out pretty good above 3k rpm

I NOTICED: it stops when i pull the clutch in

ALSO: i noticed that i put it in first with the clutch in it jumps like the clutch isnt in an it dies.

BUT: i can Put it in second and take off but first jumps and back tire spins

ANY IDEAS CLUTCH BASKET? WHAT WOULD MAKE IT KNOCK WHEN I LET THE CLUTCH OUT?

basket( I think)
http://www.youtube.com/watch?v=cyky4jMrLE4

Plates
http://www.youtube.com/watch?v=VRK1b1LI-B0

Save

1 - 1 of 42 Posts

denzee

· #5 · Dec 30, 2009

Re: SORRY GUYS BIKES GOT PROBLEMS 900RR 95

How thoroughly did you clean the carbs, just bowls or proper removal and clean? Were the carbs balanced with gauges? Should have a good run after carb rebuild to let everything settle in, then do the carb balancing.

Your temp gauge sender wire may have shorted. Find the temp sensor and trace back for short to ground. It may have come of while you did your work.

Save

1 - 1 of 42 Posts

This is an older thread, you may not receive a response, and could be reviving an old thread. Please consider creating a new thread.

Top Contributors this Month